Bunn TNT-3 Instrukcja Obsługi

BUNN-O-MATIC CORPORATION TNT-3TNTF-3POST OFFICE BOX 3227SPRINGFIELD, ILLINOIS 62708-3227TELEPHONE: (217) 529-6601 FAX: (217) 529-664428201.0000C 8

Page 10TROUBLESHOOTING (cont.)PROBLEM PROBABLE CAUSE REMEDYDilution (Iced Tea) cycle will notstart (cont.)Inconsistent beverage level indispenser (Hot

Page 11TROUBLESHOOTING (cont.)PROBLEMConsistently high or low beveragelevel in the dispenser. (cont.)Spitting or excessive steamingDrip-out time too l

Page 12TROUBLESHOOTING (cont.)PROBLEMWater flows into tank continuously(ICED/OFF/HOT Switch in the "ICEDor "HOT" position)Water flows i

Page 13REMEDYBUNN® paper filters must be usedfor proper extraction.A sufficient quantity of fresh, loosetea leaves should be used for properextractio

Page 14SERVICEThis section provides procedures for testing andreplacing various major components used in thisbrewer should service become necessary.

Page 15Location:Viewing the brewer from the rear, the hot tea brewsolenoid valve is mounted on the left side of themounting bracket.Test Procedures:1.

Page 16P1391.60FIG. 4 ICED TEA BREW SOLENOID VALVELocation:Viewing the brewer from the rear, the iced tea brewsolenoid valve is mounted in the center

Page 17Location:The hot tea brew timer is located in the hood on theleft side. It consists of a dial plate and circuit board.Test Procedure:1. Discon

Page 18SERVICE (cont.)28201 081500BREW TIMER (HOT TEA - LATE MODELS)Location:The hot tea brew timer is located in the hood, onthe left side.Test Proc

Page 19SERVICE (cont.)28201 081500BREW TIMER (HOT TEA - LATE MODELS)(cont.)1. Modifying brew volumes. To modify a brew vol-ume, first check that the

Page 2CONTENTSIntroduction ... 2Warranty ...

Page 20Location:The iced tea brew timer is located in the hood onthe right side. It consists of the dial plate and circuitboard.Test Procedure:1. Dis

Page 21SERVICE (cont.)BREW TIMER (ICED TEA - LATE MODELS)Location:The timer is located in the hood on the right side.Test Procedure.NOTE: Do not remo

Page 221. Modifying brew volumes. To modify a brew vol-ume, first check that the SET/LOCK switch is in the“SET” position on the circuit board.To incre

Page 23BUNNBUNNOFFOFFHIHILocation: The control thermostat is located inside hood onthe right side just behind the iced tea brew timer.Test Procedures:

Page 24SERVICE (cont.)DILUTION SOLENOID VALVEFIG. 16 DILUTION SOLENOID VALVEP1391.60Location:Viewing the brewer from the rear the dilution so-lenoid i

Page 25SERVICE (cont.)LIMIT THERMOSTATFIG. 18 LIMIT THERMOSTATP2213.60Location:The limit thermostat is located inside the hood onthe tank lid.Test Pro

Page 26FIG.21 ICED/OFF/HOT SWITCH TERMINALSP1367SERVICE (cont.)ICED/OFF/HOT SWITCHFIG. 20 ICED/OFF/HOT SWITCHP1370.40Location:The ICED/OFF/HOT switch

Page 27SERVICE (cont.)START SWITCHFIG. 22 START SWITCHP1370.40Location:The start switch is located in the front of the hood,above and to the right of

Page 28FIG. 24 TANK HEATERLocation:The tank heater is located inside the tank and se-cured to the tank lid.Test Procedures:1. Disconnect the brewer fr

Page 29SERVICE (cont.)THERMAL FUSE (Models W/Faucet Only)FIG. 26 THERMAL FUSEP2213.60Location:The thermal fuse is located inside the hood con-nected t

Page 3#00831.0000#00656.0000#03408.0000#03409.0000USER NOTICESCarefully read and follow all notices on the equipment and in this manual. They were wr

Page 3028201 081598

Page 4ELECTRICAL REQUIREMENTSCAUTION - The brewer must be disconnected from the power source until specified in Initial Set-Up.120V model brewers requ

Page 51. Remove the shipping cap(s) from the bulkhead fitting(s) on the rear of the brewer.2. Attach the flare fitting from the short piece of tubing

Page 613. Empty the dispenser.14. Plug in the brewer and wait for the water in the tank to heat to brewing temperature (approximately 20minutes). Som

Page 7CLEANINGCAUTION – Do not keep brewed tea overnight. Clean and sanitize your iced tea dispenser daily1. Remove and thoroughly clean the brew fu

Page 8TROUBLESHOOTINGA troubleshooting guide is provided to suggest probable causes and remedies for the most likely problemsencountered. If the prob

Page 9TROUBLESHOOTING (cont.)PROBLEMPROBABLE CAUSEREMEDYBrew cycle(s) will not start (cont.)Brew water is not hotDilution (Iced Tea) cycle will notsta